replacement of steel sludge with cement in concrete

replacement of steel sludge with cement in concrete

replacement of steel sludge with cement in concrete

Study of Effect of Lime Sludge and Silica Fume on . 2019524enspenspand waste material as a partial replacement of cement or admixture fly ash, micro silica, steel slag, lime sludge etc. are the few example of these types of material.Various mix proportions were prepared of concrete with adding lime sludge and silica fume and varying of size aggregates.

More

USE OF SEWAGE SLUDGE ASH AS A CEMENT REPLACEMENT

The partial replacement of cement with sewage sludge ash promoted an increase in the compressive and flexural strength of concrete. Meanwhile, the replacement of 5% sewage sludge ash by weight of cement was considered to be an optimum content in obtaining the best mechanical performance of concrete. Furthermore, the workability of concrete ...

More

Study on Partial Replacement of Cement with Waste Paper ...

concrete separately for replacement of sludge ash and adding glass steel fibre by cement respectively finally combined percentage of sludge ash and adding glass steel fibre in which maximum strength is obtained was used to get optimized strength. C1 is the Concentration of HCl = 35%

More

Properties of concrete containing electric arc furnace ...

Mar 01, 2020  The strength performance of concrete containing 10%–15% of steel sludge as cement replacement seemed higher than that exerted by normal concrete . Conventional concrete has some inherent drawbacks, such as low resistance towards chemical aggression [, , ]. Moisture is a primary transporter of agents of destructions into concrete, as moisture ...

More

(PDF) Experimental Study on Paper Sludge Ash as Cement ...

replacement in the concrete and conjointly up to 10% Paper Sludge Ash can replace cement in concrete because when hypo replaces cement up to 10% in c oncrete, these mix possesse s

More

(PDF) Durability Studies on Concrete with Hypo Sludge as ...

This paper summarizes the research work on the properties of hypo sludge when used as partial replacement for Ordinary Portland Cement (OPC) in concrete. OPC was replaced with hypo sludge by weight at 0%, 5%, 10%, 15%, 20% and 25%. 0% replacement

More

INFLUENCE OF CERAMIC SLUDGE WASTE AS PARTIAL

investigated in this study was M20 grade concrete with partial replacement of cement by waste material (CSW-Ceramic Sludge Waste). The percentage of replacement at the levels of 0%, 10%, 20%, 30% and 40% was examined. In this research a detailed experimental study on compressive strength and chloride permea bility were carried out at an age of 7,

More

Detailed Investigation on Concrete Using Lime Sludge

of replacement of sand by lime sludge. The investigations show that the lime sludge can be effectively used in concrete up to 10% replacement of sand without affecting much of its strength characteristics Keyword--Lime Sludge, Fly ash, replacement in cement mortar, compressive strength lead to enhanced durability characteristics. It also

More

Mechanical properties and Durability Properties of ...

strength, various replacements of sludge in cement has done. After 28 days curing, the maximum compressive strength and flexural strength with 30% replacement are 33.69% and 13.09% more than conventional concrete 3. It was found that sludge based concrete when immersed in Acid solutions has better properties with 10% replacement of concrete.

More

Usage of steel slag in concrete as fine and/or coarse ...

Usage of steel slag in concrete as fine and/or coarse aggregate ... replacement in concrete was investigated. For this purpose, steel slag was used as fine and/or coarse ... cement and steel slag were shown in Table 1. 85% of the aggregate in consist of silica, calcium, ferric, aluminum oxides. Other minor part of steel slag is

More

Experimental Studies on Partial Replacement of Cement by ...

Keeping this in view, investigations were undertaken to produce low cast concrete by blending various ratios of cement with hypo sludge. This project is concerned with experimental investigation on strength of concrete and optimum percentage of the partial replacement by replacing cement via 10%, 20%, 30%, 40%, 50%, 60% and 70% of Hypo Sludge.

More

Partial Replacement Of Cement With Steel Mill

Partial Replacement Of Cement With Steel Mill. ... Journal of Engineering Trends and Technology (IJETT) ... Experimental Investigation of Egg Shell Powder as Partial Replacement with Cement in Concrete. ... Utilization of Waste Paper Pulp by Partial Replacement of Cement in Concrete ... mill sludge can be used as an ... the partial replacement ...

More

Sewage Sludge Ash as a Partial Replacement of Cement in ...

Nov 07, 2019  By using the small amount of sewage sludge ash (SSA) mortars of comparable strength can be produced to replace cement. However, information on how SSA affects the properties of cement mortars is limited to given the Pozzolanic activities of most SSA being modest.

More

Effects of partial replacement of cement with hypo sludge ...

So our study is concerned with eco-efficient utilization of Hypo sludge as partial replacement of cement in concrete for development of low cost rigid pavement of rural road infrastructure.The ...

More

Study on hypo sludge as partially replaced cement in concrete

cement with hypo sludge is presented in this paper. Concrete specimens were prepared with 7.5%, 10%, 12.5% and 15% hypo sludge as a replacement of cement weight, The most important mechanical property of concrete is compressive strength and it is evaluated on 150X150X150 mm cubes by The

More

Experimental Study on the Properties of Concrete with ...

Soman K, et al studied the strength properties of concrete with partial replacement of cement by granite quarry dust.[1] The research work carried out included an experimental investigation on strength properties of concrete made with 2.5% to 20% replacement of cement by quarry dust of less than 75 micron. The tests were carried

More

Sewage Sludge Ash as a Partial Replacement of Cement in ...

Nov 07, 2019  By using the small amount of sewage sludge ash (SSA) mortars of comparable strength can be produced to replace cement. However, information on how SSA affects the properties of cement mortars is limited to given the Pozzolanic activities of most SSA being modest.

More

International Conference on Recent Trends in Civil ...

waste paper sludge ash as a partial cement replacement material in concrete or additive in cement introduces many benefits from economical, technical and environmental points of view. The compressive strength attains at 2%, 4%, 6% with replacement of WPSA by cement for M25 grade concrete

More

THE USE OF SEWAGE SLUDGE ASH (SSA) AS PARTIAL

replacement of cement in concrete with 5% SSA has shown lower water absorption and increase compressive strength of concrete up to 10% as compared with the control samples. Keywords: sewage sludge, waste management, concrete replacement.

More

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

the concrete maximum 20% replacement of cement by Hypo sludge in concrete in some cases 2.And increase in strength of concrete on average 10% replacements of cement by Hypo sludge in major cases.3.Workability of the concrete is decreased When percentage of Hypo sludge is increased in the concrete 4.Decrease in the

More

Effect of strength parameters in concrete with partial ...

To control environmental pollution from cement industries, Hypo sludge is used as a partial replacement of cement so that it can reduce cement content and

More

Review on Utilization of Partially Replacement of Cement ...

Review on Utilization of Partially Replacement of Cement and Sand by using Paper Mill Sludge and Sugarcane Bagasse in Concrete 1Pratik Surana , Mayur Tayade2, 3Sameer Madane , Akshay Mungase4, Manoj Deosarkar5 1,2,3,4Under Graduduation Student, Department of Civil Engineering DYPSOET Pune, Maharashtra India

More

The Mechanical Properties of Concrete Incorporating Steel ...

Mix designs are determined with replacement proportion of cement by SS of 0, 10%, 20%, 30%, 40% and 50%. Results show that replacement of cement by SS up to 50% increase the workability of concrete. The density of concrete ranges from 2083 to 2373 kg/m3, with and without replacement of SS at curing age of 1-day, 3-day and 28-day.

More

Effect of Hypo Sludge as Partial Replacement of Cement in ...

Mar 16, 2017  Effect of hypo sludge as partial replacement of cement in concrete (IJSRD/Vol. 4/Issue 05/2016/201) Science, Engineering and Technology, pp. 5499–5507, 2016. [9]

More

Study on flexural strength of concrete with partial ...

The use of waste materials as replacement of natural resources is one of the best approaches to improve sustainability. Paper mill sludge (Hyposludge) is a major economic and environmental problem for the paper and board industry. Most of the wastes sent to dumping sites and landfills. These waste materials could be incorporated in concrete manufacturing as a replacement for cement due to its ...

More

Study of Concrete Involving Use of Waste Paper Sludge Ash ...

In this study waste paper sludge ash was partially replaced as 5%, 10%, 15% and 20% in place of cement in concrete for M-25 mix and tested for its compressive strength, tensile strength, water ...

More

Effects of partial replacement of cement with hypo sludge ...

Nov 27, 2018  Hypo sludge in concrete beams, 150 mm × 150 mm × 700 mm in size, were tested under single point loading. The results presented that the compressive, split tensile and flexural properties of concrete matrix are meaningfully improved by the addition 20% on of hypo sludge by cement in concrete.

More

Effect of steel slag and steel sludge on concrete ...

The wastes generated from steel industries are known to be as sludge and slag. The problem with some of these by-products is they contain large amount of heavy metals that can be leached out to the environment and cause pollution. Several studies have been conducted on steel slag as a replacement for cement in concrete but it is still not sufficient and well established.

More

Sewage Sludge Ash as a Partial Replacement of Cement in ...

Nov 07, 2019  By using the small amount of sewage sludge ash (SSA) mortars of comparable strength can be produced to replace cement. However, information on how SSA affects the properties of cement mortars is limited to given the Pozzolanic activities of most SSA being modest.

More

Study of Concrete Involving Use of Waste Paper Sludge Ash ...

This research will summarize the behavior of concrete with the waste paper sludge ash by replacement of cement in the range of 5%, 10%, 15% and 20% which may help to reduce the disposal problem of ...

More

Papercrete: A Study of Paper Effluent Treatment Sludge as ...

3) Comparison of cost of nominal mix concrete and effluent sludge concrete. The objective of this project is to find the compressive strength, split tensile strength and workability of concrete with blended effluent sludge cement. The water-to-binder ratio will be taken as 0.45 and four different replacement percentages of effluent

More

Partial Replacement Of Cement With Steel Mill

Partial Replacement Of Cement With Steel Mill. ... Journal of Engineering Trends and Technology (IJETT) ... Experimental Investigation of Egg Shell Powder as Partial Replacement with Cement in Concrete. ... Utilization of Waste Paper Pulp by Partial Replacement of Cement in Concrete ... mill sludge can be used as an ... the partial replacement ...

More

CHARACTERIZATION OF SEWAGE SLUDGE ASH (SSA) IN

determine the potential use of SSA in cement and concrete based material in Malaysia seems to be lacking. Hence, the aim of this study is to characterize the raw sewage sludge obtained in Kuantan, Malaysia and incinerated sewage sludge at 600°C and 800°C with 10% replacement in cement mortar. MATERIALS Sewage Sludge

More

Partial replacement of cement concrete by waste materials

Sludge (SS) and corn cob ash (CDA) are used in replacement of cement and reduce the cost of concrete production by making use of locally available materials. 1.1 SAW DUST Saw dust is a waste material from the timber industry. It is produced as timber is sawn into planks at saw mills located in virtually all major towns in the country.

More

Review Paper on Partial Replacement of Cement and ...

May 10, 2019  To deal with these, alternate materials were tested experimentally for use in preparing concrete. Properties of a number of materials such as steel fibre, asphalt, slag, asbestos, lead, dry sludge, wet sludge, fly ash, bagasse ash, red mud, plastic, glass, etc., were studied to find an alternative for replacement of cement.

More

STUDY OF STEEL SCRAP REINFORCED CONCRETE WITH

concrete and, the optimum combination of using both bagasse ash as a p artial replacement material for cement and addition of steel scrap to the concrete, is determined. Keywords: bagasse ash, steel scrap, compression test, split tensile test, flexural test. 1. INTRODUCTION Ordinary Portland cement is

More

A Study on Application of Pickling Sludge in Pavements Tiles

All the concrete was mixed in Hand Feed Concrete Mixer. The speed of the mixer was about 25 rpm. All cement-sludge concrete cubes were cast in cast iron mould at 27± 2 °C. For compaction of concrete cubes vibrating Table was used. The Vibrating Table was operated by 5 HP motor with speed of 12000± 400 rpm. All the concrete cubes were cured

More

Assessment of the properties of sustainable concrete ...

Use of glass powder in the production of self compacting concrete is recommended by Rehman et al. (2018), where the combined effect of glass powder with granular steel slag as replacement to cement and fine aggregate on mechanical properties is studied. The obtained results show that when cement is replaced with 20% glass powder and fine ...

More

Utilization of Rice Husk Ash and Waste Paper Sludge Ash as ...

waste paper sludge ash as partial replacement of cement in various percentages.In this project Rice Husk Ash (RHA) and Waste Paper Sludge Ash (WPSA) obtained from uncontrolled combustion are used as an alternative construction material for concrete.

More